Power Pack Options
|
Remote Power Pack |
 |
The Remote Power
Pack option allows the hydraulic power unit and electrical panel box to be
mounted separately from the packer. Remote Power Units are used in applications
where the packer is installed in a locations which may occasionally flood, is
subject to dust or other harsh conditions. Push buttons are mounted in the face
of the electrical panel box or, if specified, as a separate assembly connected
to 13' Sealtite. Hydraulic couplings are welded in the side of the compactor.
The power unit is connected to the compactor by two 7 foot wire braided hoses. A
steel Weather Cover an NEMA 3R Electrical Panel Box is provided to protect the
components. The Weather Cover tilts back for maintenance and easy access to the
hydraulic components. Mark-Costello manufactures its power units with only the
highest quality components. |
|
Top of Page
Oil Cooler |
|
|
When the compactor operates for
long periods of time without shutdown, the power unit should be equipped with an
Oil Cooler. |
|
Top of Page
Oil Heater - Thermostatically Controlled |
 |
The Thermostatically
Controlled Oil Heater is installed in the oil reservoir and is equipped with
a manually adjustable thermostat control so that the heater is functioning only
when required (does not have to be disconnected during the summer months.) Its
temperature range cannot exceed 100 degrees Fahrenheit. |
|
Top of Page
Tri-Volt Option |
|
|
The Tri-Volt Option is
offered as a time saver and for convenience. With this option, it is very easy
to convert from 3 phase/208 volt to 230, to 460 and back to 208 volt. The only
additional parts needed are the overload heater elements (sized to voltage and
motor size - see chart in compactor's electrical panel box.) This option
consists of a tri-volt transformer, motor and motor starter sized large enough
for any of the 3 voltages. Voltage changes are made by rewiring the motor and
the transformer and changing heating elements. The Tri-Volt Option is available
for all Mark-Costello Compactors. |
Top of Page
Odor Control Systems
|
Ozone Odor Control System |
 |
The Ozone Odor
Control System
generates ozone, a powerful oxidizer which breaks down odor molecules and
converts them into water vapor and other odorless, harmless gases. In addition
to eliminating all odors from the air, the ozone-rich atmosphere inhibits germ
and bacteria growth. The system requires no chemicals or fragrances and only
incidental, routine service. All units except those installed on Vert-I-Pack
Compactors require a separate 110 volt power source. |
|
Top of Page
Deodorant Spray System |
 |
The Deodorant Spray System
consists of an electrical pump with enclosure, a 5 gallon reservoir and
spray head(s). The pump operation is energized on the forward stroke of the
packer ram. The reservoir is a polyethylene container which is removable for
easy remote filling or, if installed on non-remote Horizontal Packers, the
reservoir is accessible for refilling through a hinged cover in the packer top
cover. |
Top of Page
Option Pages: [<<
previous page] 1 | 2
| 3 | 4 | 5 [next page >>]
|
|
RELATED |
Container Fullness Measuring Systems
Container Usage Measuring Systems
Cycle Control Systems
Odor Control Systems
Power Pack Options
Steel Options
|
|
